.png)
.png)
.png)
.png)
ra
Stone putty EASY1
- ity unsatu ra ted polyester resin /uplo - on unsatu ra ted polyester resin.
- -2 kg
Sto ra ge period: 9 months
EA - ity unsatu ra ted polyester resin.Easy
Putty ، stone ، A2P ، polyester putty ، sadrapaint ، ghavampaint ، ،
Runs
- correct sp ra ying viscosity, sp ra ying - fective sp ra y gun set up
• Incorrect - s
• De sp ra ying pressure
• Tempe ra t - int, subst ra te or sp ra ybooth too low - t-Defects/ ra ins.jpg Runs
Cause
runs ، caus ، spraying ، flash ، coat ، prevention ، thinner ، hardeners ، paint ، spray ، sheets ، spray gun ، aterial ، combine ، ،
Clouding
- correct sp ra ying viscosity, sp ra ying - times, sp ra ybooth tempe ra ture
• Def - fective sp ra y gun set up, incorrect s - flash-ofp ra ying pressure
• Unsuitab - times, sp ra ybooth tempe ra ture
&bu
spraying ، viscosity ، technique ، spraybooth ، pressure ، gun ، thinner ، material ، parallel ، anufatures ، thinner ، conventional ، method ، surface ، repaint ، clear ، ،
.JPG)
Solvent popping
- t or air t ra pped in film, which then - correct sp ra ying viscosity, sp ra ying - below deco ra tive strips
• Sol - ; Wrong sp ra ying technique
- oven tempe ra ture regularly
•
fill ، pinnholes ، polyester ، spray ، filter ، remove ، damage ، finish ، repair ، drying sanding ، thicknesses ، sand ، viscosity ، air ، solvent ، hardness ، thinner ، ،
Orange peel
- O ra nge peel Incorrect sp ra ying press - cosity, sp ra ying technique or applica - tion tempe ra ture
Unsuitable combina - g of subst ra te /uploadfile/file_porta - -Defects/o ra nge.JPG O ra nge peel
Ca
spray ، viscosity ، technique ، low ، quality ، solvent ، sustrate ، temperature ، application ، sand ، substrate ، thinner ، hardner ، ،
Edge mapping due to solvent penetration
- vent penet ra tion Area where topcoat - h to subst ra te not isolated
Isolate - g of subst ra te /uploadfile/file_porta - vent penet ra tion
Cause
• A - h to subst ra te not isolated
•
insufficient ، drying ، substrate ، filter ، primer ، unsuitable ، isolated ، spray ، coat ، observe ، flash ، avoid ، sanding ، soft ، repaint ، ،
Dirt and dust in basecoat
- ure the sp ra ybooth is clean at all ti - e of prepa ra tion
• Wear lint - tagfree sp ra ysuit
• Use paint - every s st ra iner/filter
Remed
paint ، straine ، filter ، spraysuit ، dust ، remove ، stage ، preparation ، required ، areas ، repply ، basecoat ، dirt ، particles ، ،
Dirt and dust in clearcoat
- irt is att ra cted to the clearcoat and - on, d is t ra pped in the wet film
• I - on, d is t ra pped in the wet film
& - ure the sp ra ybooth is clean at all ti - e of prepa ra tion
• Wear lint
surface ، trapped ، dark ، light ، specks ، depend ، clearcoat ، clean ، spraybooth ، ensure ، crevices ، preparation ، wear ، free ، spraysuit ، ،
Poor opacity
- city Subst ra te not uniform (Effect fi - ull; Subst ra te not uniform (Effect fi -
• Sp ra y a uniform subst ra te
-
• Sp ra y sufficient topcoat to o
coating ، overthinned ، topcoat ، finish ، substrate ، spray&uniform ، sufficient ، obtain ، opacity ، excessive ، amount ، thinner ، ،
Moisture blisters
- below deco ra tive strips
Contaminated - below deco ra tive strips
• Con - ing and sp ra ying, clean according to
repaint ، finish ، contaminated ، remove ، spray ، clean ، instruction ، product ، curing ، dry ، carefully ، air ، remove ، eterior ، ،
